Product ID:SOLVENTBORNE NEOPRENE ADHESIVE, MA212
MSDS Date:10/03/1997
FSC:8040
NIIN:00-664-4318
Status Code:A
MSDS Number: CLKWC

TACC INTERNATIONAL CORP

AIR STATION INDUSTRIAL PARK
ROCKLAND, MA 02370
US

Emergency Phone: 800-424-9300

Info Phone: 781-878-7015

Preparer: RYAN MICKELSON

Cage: 0HZU1

TACC INTERNATIONAL CORP

ROCKLAND, MA 02370 US

Telephone: 781-878-7015

Cage: 0HZU1

TOLUENE

CAS: 108-88-3

RTECS: XS5250000

OSHA PEL see Table Z-2

ACGIH TLV: 188 MG/M3;50 PPM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

HEXANE

CAS: 110-54-3

RTECS: MN9275000

OSHA PEL 1800 MG/M3;500 PPM

EPA Report Quantity: 1 LB

DOT Report Quantity: 1 LB

ACETONE

CAS: 67-64-1

RTECS: AL3150000

OSHA PEL 2400 MG/M3;1000 PPM

ACGIH TLV: 1780 MG/M3;750 PPM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

METHYL ETHYL KETONE

CAS: 78-93-3

RTECS: EL6475000

OSHA PEL 590 MG/M3;200 PPM

ACGIH TLV: 590 MG/M3;200 PPM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

Effects of Overexposure:INHALATION: ACUTE SIGNS OF OVEREXPOSURE COULD
BE HEADACHE, DIZZINESS, NAUSEA, UPPER
REPIRATORY DRYNESS OR IRRITATION, DROWSINESS, MENTAL DEPRESSION OR
NARCOSIS,
DIFFICULTY IN BREATHING. CHRONIC EFFECT S OF OVEREXPOSURE TO SOLVENT
VAPORS COULD
LEAD TO PERMANENT EFFECTS TO THE NERVOUS SYSTEM, BODY ORGANS, OR THE
BRAIN. USE
WITH ADEQUATE VENTILATION. EYES: IRRITATION. SKIN: REMOVAL OF SKIN
OILS, IRRI TATION,
DERMATITIS, EVEN SENSITIZATION WITH LONG OVEREXPOSURE. INGESTION: MAY
BE HARMFUL OR
FATAL IF SWALLOWED.

First Aid:INHALATION: GET FRESH AIR, IF NECESSARY CALL PHYSICIAN. SKIN:
WASH WITH MILD SOAP AND
WATER, APPLY A MILD CREAM. EYES: FLUSH WITH WATER FOR AT LEAST 15
MINUTES. INGESTION:CALL POISON CENTER IMMEDI ATELY.

Flash Point Method:TCC
Lower Limits:1.1
Upper Limits:12.8
Extinguishing Media:FOAM, DRY CHEMICAL, CARBON DIOXIDE, WATER SPRAY OR
FOG.
Fire Fighting Procedures:AVOID BREATHING SMOKE. USE AIR SUPPLIED RESCUE
EQUIPMENT FOR ENCLOSED AREA. WATER TENDS TO SPREAD BURNING LIQUID
IF LARGE AMOUNTS USED.
Unusual Fire/Explosion Hazard:FLAMMABLE. VAPORS MAY IGNITE EXPLOSIVELY
AND/OR CAUSE FLASH FIRES. ELIMINATE SOURCES OF IGNITION. NO
SMOKING. USE ADEQUATE CROSS VENTILATION SUFFICIENT TO REMOVE ODOR
OF SOLVENT AND VAPORS. ELECTRICAL LY GROUND ALL CONTAINERS DURING
TRANSFER.

Spill Release Procedures:SMALL QUANTITIES MAY BE ABSORBED INTO AN
APPROPRIATE ABSORBENT. FOR LARGE SPILLS SEE
SECTIONS 4,7,11

Handling and Storage Precautions:KEEP CONTAINER CLOSED WHEN NOT IN USE.
STORE AT 60-95 DEGREES F., AND OUT OF THE SUN.
USE ADEQUATE VENTILATION TO AVOID BREATHING VAPORS WHEN COVER IS
REMOVED. GROUND
ALL EQUIPMENT WHEN HANDLING FLAMM ABLE SOLVENTBORNE MATERIALS.

Respiratory Protection:IF VAPORS EXCEED TLV USE SELF CONTAINED ORGANIC
MASK NIOSH APPROVED.
Ventilation:SUFFICIENT TO KEEP WORKROOM CONCENTRATION BELOW TLV.
Protective Gloves:CHEMICAL RESISTANT GLOVES
Eye Protection:SAFETY GLASSES OR FACE SHIELD
Other Protective Equipment:BARRIER CREAM FOR SENSITIVE SKIN.
Supplemental Safety and Health

Boiling Pt:B.P. Text:133-231 DEG F
Spec Gravity:0.87755
Solubility in Water:LIGHTER THAN WATER
Percent Volatiles by Volume:73.6

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG ACIDS AND BASES.
Stability Condition to Avoid:FIRE, SPARKS, STATIC ELECTRICITY.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE.

Waste Disposal Methods:MATERIAL IS DESIGNATED AS HAZARDOUS WASTE UNTIL
ALL SOLVENTS AND VAPORS HAVE
EVAPORATED. DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE, AND FEDERAL
REGULATIONS.
DRIED ADHESIVE MAY BE DISPOSED OF AS ORDIN ARY WASTE.

SARA Title III Information:THIS PRODUCT CONTAINS THS FOLLOWING TOXIC
CHEMICALS SUBJECT TO THE REPORTING REQUIREMENTS OF SECTION 313 OF
THE EMERGENCY PLANNING AND COMMUNITY RIGHT TO KNOW ACT OF 1986 AND
OF 40 CFR 372 108-88-3 TO LUENE <5, 110-54-3 HEXANE <50, 78-93-3
METHYL ETHYL KETONE <20,
State Regulatory Information:THIS PRODUCT CONTAINS A CHEMICAL KNOWN TO
THE STATE OF CALIFORNIA TO CAUSE CANCER. THIS PRODUCT COTAINS A
CHEMICAL KNOWN TO THE STATE OF CALIFORNIA TO CAUSE BIRTH DEFECTS OR
OTHER REPRODUCTIVE HARM.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.